1995 Saturn Wagon Clutch Slave Cylinder: Service and Repair
download Hydraulic Clutch Control System IMPORTANT: The clutch hydraulic system is to be serviced as a COMPLETE UNIT!!!. It is a sealed unit and has been filled with fluid and bled of air at the...
View Article2002 Dodge RAM 2500 46RE AUTOMATIC TRANSMISSION DIAGNOSIS AND TESTING – ROAD...
download Before road testing, be sure the fluid level and control cable adjustments have been checked and adjusted if necessary. Verify that diagnostic trouble codes have been resolved.Observe engine...
View Article2002 BMW 525I 2003 BMW X5 2001 BMW Z3 Roadster Check engine light is on.
download 1. Use a scan tool to monitor the fuel trim numbers and the Mass Air Flow (MAF) sensor data stream grams/sec readings. Nominal values are 5 grams/sec at idle in Park, and >150 at Wide Open...
View Article2006 – 2007 Mazdaspeed6 CLUTCH PEDAL IS DIFFICULT TO OPERATE
download When releasing the clutch, the height of the pedal where the clutch starts to engage is higher than other vehi- cles making a smooth engagement difficult. Higher pedal pressure is required to...
View Article1996 Ford Bronco/ F-Series Clutch Hydraulic Line Removal Installation
download Removal 1. Note the routing of the clutch slave cylinder to clutch master cylinder tube (7A512) line from clutch master cylinder (7A543) to the clutch slave cylinder. 2. Remove retainer pin...
View Article1988-90 Ford Super Duty HIGH CLUTCH EFFORT/ CLUTCH FLUID LEAK – CRACKED MOUNT
download Incomplete clutch release and/or hydraulic fluid leaking into the cab from the clutch master cylinder may be caused by the reinforcement plate on the clutch master cylinder separating from the...
View Article2007-2009 FORD Mustang SHELBY GT500 CLUTCH DRAG
download 2007-2009 Mustang Shelby GT500 vehicles may exhibit the following clutch/transmission symptoms: hard to disengage or engage 1st and reverse, hard to shift any gear, gear grinding during shifts...
View Article2001 Ford F-150 Clutch Master Cylinder/ Reservoir REMOVAL AND INSTALLATION
download Removal NOTE: When replacing clutch master cylinder (7A543), remove tubing from vehicle for bench bleeding procedure. 1. Disconnect the clutch master cylinder push rod from the clutch and...
View Article2000 Ford F-Super Duty 250-550 Clutch Master Cylinder and Reservoir REMOVAL...
download Removal CAUTION: Remove the entire clutch hydraulic system from the vehicle as an assembly when installing a new clutch master cylinder assembly (7C522). 1. Disconnect the clutch hydraulic...
View Article2005–2006 Toyota Tacoma CLUTCH PEDAL SQUEAK NOISE
download Some customers may complain about a “squeak” or “creak” noise when depressing or releasing the clutch pedal. The clutch master cylinder clevis assembly has been improved to eliminate this...
View Article
